2003 Arctic Cat ATVs from 250cc to 500cc Service Manual, Page 528Get this manual

2003 Arctic Cat ATVs from 250cc to 500cc Service Manual, Page 528

Problem: Magneto overcharges Condition 1Internal battery short circuited Remedy 1Replace battery 2Regulatorrectifier resistor
on surfaces of cell plates) Condition Remedy 1Charging rate too lowtoo high 1Replace battery 2Battery electrolyte excessiveinsufficient
3Specific gravity too hightoo low 4Battery run-downdamaged 5Electrolyte contaminated Problem: Battery discharges too rapidly
Condition 1Electrolyte contaminated 2Specific gravity too high 2Keep electrolyte to prescribed level 3Charge batteryadd distilled
water 4Replace battery 5Rechargereplace battery Remedy 1Replace battery 2Charge batteryadd distilled water 3Charging system
(charging operation) not set 3Check magnetoregulatorrectifiercircuit properly connectionsadjust for specified charging operation
4Cell plates overchargeddamaged 5Battery short-circuited 6Specific gravity too low 7Electrolyte contaminated Problem: Battery