2004 650 Twin Arctic Cat ATV Service Manual, Page 96Get this manual

2004 650 Twin Arctic Cat ATV Service Manual, Page 96

Water PumpAlternator Cover NOTE: Check for water pump seal leakage by examining drain catch tank (A) AT THIS POINT If the
of the alternator cover using bearing driver (C) 1Drain the coolant; then remove hoses (A), cap screws (B), and the water
pump cover (C)Account for the gasket and two alignment pins ATV2114 ! CAUTION 2Remove the recoil starter (see Removing Left-Side
Components in Section 3); then using suitable holding wrench (B) to hold the starter cup (A), loosen the impeller (C) by
turning counterclockwise If the mechanical seal, oil seal, or the ball bearing is removed, always replace all three as setBe
careful not to block the inspection hole with the oil sealIf the inspection hole is blocked, coolant will pass through the