1994 Johnson/Evinrude "ER" CV 85 thru 115 outboards Service Manual, Page 264Get this manual

1994 Johnson/Evinrude "ER" CV 85 thru 115 outboards Service Manual, Page 264

Tilt Limit Switch Isllsl lf the engine contacts the boat's motor well when fully adjust the tilt limit cam to lower full-tilt
or modifying the boat if the possibility for interference and damage exists Routine Inspections 1Check reservoir fluid level
at least once per season or every 50 operating hoursSystem capacity is approximately 21 flo oz(622 ml) Tilt the engine up
and engage the tilt support Remove the fill cap and add OMC Power TrimlTiltPower Steering Fluid or GM Dexron II, as needed,
to bring fluid level up to the bottom of the fill cap hole Replace fill cap and disengage tilt supportCycle unit down, then
up; pausing between cycles and adding fluid as neededA minimum of five complete cycles is required to purge air drawn in
because of low fluid level2Look for indications of external fluid leakageCorrect the cause if leaks are noted 3Torque the
manual release valve to 45-55 inIbs(5-6 4Inspect the stern brackets for binding with the swivel bracket in the trim limiter