1995 Johnson Evinrude "EO" 90 CV 85 thru 115 Service Manual, P/N 503150, Page 263Get this manual

1995 Johnson Evinrude "EO" 90 CV 85 thru 115 Service Manual, P/N 503150, Page 263

Tilt Limit Switch f51ls' lf the engine contacts the boat's motor well when fully adjust the tilt limit cam to lower full-tilt
provide additional motor well clearance when it's neededConsider either changing the engine mounting position or modifying
the boat if the possibility for interference and damage exists Routine Inspections f'7l 1Check reservoir fluid level at least
once per season or every 50 operating hoursSystem capacity is approximately 21 floz(622 mil Tilt the engine up and engage
the tilt support Remove the fill cap and add OMC Power TrimlTiltPower Steering Fluid or GM Dexron II, as needed, to bring
fluid level up to the bottom of the fill cap hole Replace fill cap and disengage tilt supportCycle unit down, then up; pausing
between cycles and adding fluid as neededA minimum of five complete cycles is required to purge air drawn in because of low
fluid level2Look for indications of external fluid leakageCorrect the cause if leaks are noted '" 3Torque the manual release