1996 Johnson Evinrude "ED" 40 thru 55 2-Cylinder Service Manual, P/N 507124, Page 33Get this manual

1996 Johnson Evinrude "ED" 40 thru 55 2-Cylinder Service Manual, P/N 507124, Page 33

Break-In Procedure During the first 12 gallons of fuel you must use 50:1 fuel oil ratio in your fuel tank in addition to
throttle settingChange engine RPM often First 20 Minutes Operate engine in gear at fast idle ONLY Verify water pump operation
by looking for steady stream of water at the water pump indicatorNext 40 Minutes DO NOT operate engine above half throttle
(no more than 3500 RPM) DO NOT hold constant throttle setting Change engine speed every 15 minutes Verify water pump operationI
Note With easy planing boats, use full throttle to quickly accelerate boat onto planeImmediately reduce throttle to one-half
as soon as boat is on planeBE SURE boat remains on plane at this throttle setting Next Nine Hours ._ Avoid continuous full-throttle
operation Verify water pump operation Bring boat onto plane and operate engine below 3f4 throttle (no more than 4500 RPM)
Every 30 minutes, operate engine at full throttle for approximately one minute DO NOT exceed recommended maximum engine RPMRefer