1996 Johnson Evinrude "ED" 60 LV 90, 115, 150, 150C, 175 Service Manual, P/N 507127, Page 281Get this manual

1996 Johnson Evinrude "ED" 60 LV 90, 115, 150, 150C, 175 Service Manual, P/N 507127, Page 281

Tilt Lim it SwitchFasTrak If the engine contacts the boat's motor well when fully tilted, adjust the tilt limit cam to lower
mounting position or modifying the boat if the possibility for interference and damage exists Routine InspectionsFasTrak
rn 1.50Check reservoir fluid levelcapacity isonce per season or at least every operating hoursSystem approximately 21 floz(622
ml) Tilt the engine up and engage the tilt support Slowing open fill capallowing air to escapeAdd OMC Power TrimlTiltPower
Steering Fluid or GM Dexron II, as needed, to bring fluid level up to the bottom of the fill cap hole Replace fill cap and
disengage tilt supportCycle unit down, then up; pausing between cycles and adding fluid as neededA minimum of five complete
cycles is required to purge air drawn in because of low fluid level2Look for indications of external fluid leakageCorrect
the cause if leaks are noted 3Torque the manual release valve to 45-55 inIbs(5-6 Nm) 4Inspect the stern brackets for binding