2003 Polaris Freedom, Virage and Genesis PWC Service Manual, Page 281Get this manual

2003 Polaris Freedom, Virage and Genesis PWC Service Manual, Page 281

Fuel Injection System FICHT Troubleshooting"ENGINE TURNS- OVER, BUT WILL NOT START" Test startstop switch and related harnesses
pressing start button Starter Motor Voltage Drop Test Ignition Coils Use PODIAG to test coil functionsDisconnect injector
from harnessDoes engine start? If not, stator, EMM, injector(s), andor harness at fault Measured Voltage on 45V (FICHT) circuits
Specified Stator Output Battery charge will affect vAC readingsCharge battery to 12.5vDCReplace stator if ANY pins show continuity
to groundTo test, obtain known, good EMMConnect and 12-pin harnesses from boat to this EMMAttempt to start engineCheck ALL
EMM ground pins in harness and engine blockbatteryFuel pressure20 to 30 psiA failed sensor may not show code, or illuminate
CHK ENG lampUse "ENGINE MONITORING function to view sensor dataReference "ENGINE MONITORING" screenENGINE SYNC should read
"YES" when pushing start buttonALTERNATOR VOLTAGE should "step-up" to approximately 22 vDCWhen MAG piston is at TDC, encoder